Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB077  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  CRACKER BARREL OLD COUNTRY STORE #221 Address  50 KEN HAYES DR
Owner or Operator   CBOCS WEST, INC City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
X
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
X
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
X
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
X
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes     No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 50-100 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   raw chicken 35, gravy 162, steak 36, caserole 156, potatoes 160, chicken 165, chicken & dumpling 156, mashed potatoes 170, hash browns 170, beans 153, pot. roast 145, beef stew 174, meat loaf 153, brocoli soup 153, gravy 150, bacon 35, chicken salad 38, chicken -6, sausage -16, potato soup 154
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/03/2010 Time In  1:15 PM Time Out  3:00 PM Sanitation Score  80 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  90  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB077  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CRACKER BARREL OLD COUNTRY STORE #221 Address  50 KEN HAYES DR
Owner or Operator   CBOCS WEST, INC City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*1  Observed the following foods to be unwholesome/spoiled. Onions in the dry storage area had mold growth on them. Provide for all foods to be wholesome and free from spoilage. Onions were thrown away. 750.100 Immediate/Onsite
*41  Observed the sanitizer solution in/at the following location(s) to be too strong: Sanitizer bucket was too strong under prep table. Provide for the sanitizer solution to be no stronger than the required concentration. Employee adjusted sanitizer. 750.820 Immediate/Onsite
5  Observed no thermometer to be available in the following units. There was no visible thermometer for the whipped cream cooler on prep line. Provide for an accurate, conspicuous thermometer, that is accurate within +/- 3°F, to be available in all units holding potentially hazardous foods. 750.140 Next Inspection
8  Observed the following food products to be improperly stored. There was no lids on beans or sugar. Provide for all food products in storage to have proper covers or overhead protection. 750.130 Next Inspection
15  Observed the following improper non-food contact surfaces. There is rust on the pan shelf. Remove all rust from this shelf & repaint & seal it. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.690 Next Inspection
22  Observed the following food contact surfaces to be unclean. Top of the microwave has food debris on it. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. 1. Gas pipes has grease & debris on them. 2. Sides of stove has grease & debris on them. 3. Interior of fryers has grease & debris on them. 4. Brown sugar was located on back dry storage shelf. Clean and maintain Next Inspection
29  Observed the following plumbing to be improperly installed or maintained: There is a leak located under the three compartment sink. Provide for all plumbing to be sized, installed, and maintained in accordance with applicable provisions of the Illinois State Plumbing Code. All Plumbing modifications and/ or upgrades will be required to be permitted to inspected by the local plumbing inspector. 750.1060 Next Inspection
34  Observed the dumpster area to be unclean Provide for the dumpster area to be kept clean so as to not be an attactive nuisance. 750.1150 Next Inspection
36  Observed the following floor areas to be unclean: Floor in the walk-in freezer has food debris on it. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/03/2010 Time In  1:15 PM Time Out  3:00 PM Sanitation Score  80 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  90  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB077  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CRACKER BARREL OLD COUNTRY STORE #221 Address  50 KEN HAYES DR
Owner or Operator   CBOCS WEST, INC City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/03/2010 Time In  1:15 PM Time Out  3:00 PM Sanitation Score  80 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  90